Results 1 to 13 of 13

Thread: CX-9 has musty mold smell when A/C runs and tried everything to fix

  1. #1
    Registered Member

    2012 Mazda CX9 Touring

    Join Date
    Jan 2018
    Location
    Wisconsin
    Posts
    3

    CX-9 has musty mold smell when A/C runs and tried everything to fix

    My wife's 2012 CX-9 has a musty mold like smell whenever her A/C kicks on. We bought it Certified Pre-Owned in 2014 with 44k miles and it didn't do it then. It has been doing it for the last 2 years and she's sick of it.

    I've gone to the following projects to solve the problem with no success.

    1) I've ran Lysol through the HAVC system.

    2) I've had the vents professionally cleaned by a detail company with vacuums and vent dusters.

    3) I've removed the glove box to inspect the white plastic basins under and to the left of the blower to inspect for excessive (or any) fluids and found nothing. I also found pure white translucency when holding a LED flashlight up to it to inspect for possible mold/mildew growth.

    4) I've jacked up the car and hooked a shop vac up to he AC evaporator drain. No fluids or gunk were removed.

    5) The cabin filter is pristine.

    Any suggestions? It is to the point she wants to sell the car because of this issue. I smell it too and it is gross.

    Thanks,
    Steve

  2. #2
    Banned GJ-Molestor's Avatar

    2011 BMW 528i, 2015 Mazda 6, 1995 Nissan Maxima Manual

    Join Date
    Apr 2017
    Location
    Toronto
    Posts
    1,798
    Quote Originally Posted by wifescx9 View Post
    My wife's 2012 CX-9 has a musty mold like smell whenever her A/C kicks on. We bought it Certified Pre-Owned in 2014 with 44k miles and it didn't do it then. It has been doing it for the last 2 years and she's sick of it.

    I've gone to the following projects to solve the problem with no success.

    1) I've ran Lysol through the HAVC system.

    2) I've had the vents professionally cleaned by a detail company with vacuums and vent dusters.

    3) I've removed the glove box to inspect the white plastic basins under and to the left of the blower to inspect for excessive (or any) fluids and found nothing. I also found pure white translucency when holding a LED flashlight up to it to inspect for possible mold/mildew growth.

    4) I've jacked up the car and hooked a shop vac up to he AC evaporator drain. No fluids or gunk were removed.

    5) The cabin filter is pristine.

    Any suggestions? It is to the point she wants to sell the car because of this issue. I smell it too and it is gross.

    Thanks,
    Steve
    I guess you're just gonna have to keep looking through the whole system for the source of the smell. It'll be there somewhere...

  3. #3
    Registered Member babyluv1's Avatar


    Join Date
    Dec 2006
    Posts
    63
    How many miles on it? Have you checked the vents outside of the car? Does it smell when the ac is recirculating air? Do you have a moon roof? Is the car parked outside or in a garage? How often does she run the heater? Are the floors damp? I'm asking a bunch of random ass questions because you might not have just a problem with the ac.

  4. #4
    ZOOOOOOOOOM ZOOOOOOOOOOOM mazdadude's Avatar

    '16.5 Mazda CX-5 Touring AWD, '05 PRIUS

    Join Date
    Dec 2005
    Location
    Red Bluff, CA
    Posts
    3,540


    Last edited by mazdadude; 01-21-2018 at 11:55 PM.
    Mazda's I have owned over the years. (boom07)
    80' Mazda GLC SPORT MT - sold
    81' Mazda 626 DX MT - sold
    81' Mazda 626 LX AT - sold
    82' Mazda 626 DX MT - sold
    82' Mazda 626 LX AT - sold
    85' Mazda 626 LX MT - sold
    87' Mazda 626 GT Turbo MT - sold
    85' Mazda RX-7 GSL-SE MT- sold
    87' Mazda RX-7 Turbo 2 MT - sold
    91' Mazda Protege LX MT - sold
    92' Mazda MX-5 Miata MT - sold
    93' Mazda MX-3 GS-V6 Special Edition MT - sold
    00' Mazda 626 LX-V6 MT - sold
    02.5' Mazda Protege5 MT - sold
    92' Mazda MX-5 Miata MT - sold
    06' Mazda 5 Touring AT - sold
    13' Mazda CX-5 Touring AT - sold
    14' Mazda 3i Grand Touring MT - sold
    15' Mazda CX-5 Touring AWD AT - sold
    03' Mazda Protege5 AT - sold
    09' Mazda Mazdaspeed3 GT - sold
    16.5' Mazda CX-5 Touring AWD AT - current

  5. #5
    Registered Member

    2012 Mazda CX9 Touring

    Join Date
    Jan 2018
    Location
    Wisconsin
    Posts
    3
    82k miles. Inspected exterior intake vents. Smells primarily when A/C is on with and without recirculating on. We have a moon roof but no oder comes from it and it is a good seal. Park inside every day. Heater runs often since we live in Wisconsin. Floors are not damp. Smell is still present even a year after I made my original post.

  6. #6
    Registered Member

    2012 Mazda CX9 Touring

    Join Date
    Jan 2018
    Location
    Wisconsin
    Posts
    3
    We've taken it to a dealer to have a foaming cleanser service performed. I've also done two of my own applications just like the dealer did, via the blower fan area that leads into the HVAC system behind the center console. I've also applied foaming cleanser through the top center console vents so that it drops down onto the condenser unit, after looking at how the CX-9 is put together on a schematic. That way I'm attacking they HVAC system in both directions. No gunk comes out of the drain under the car, just foam cleanser. Once the foam settles, it just looks like clear liquid.

  7. #7
    Registered Member babyluv1's Avatar


    Join Date
    Dec 2006
    Posts
    63
    I had a similar problem with my Mazda 3 and it ended up being the carpet and floor mats. Water was getting underneath the floor mats causing the carpet to smell. I sprayed the mats and carpet with peroxide, then put down a little baking soda, then sprayed vinegar, then used a mini green machine and hot water/vinegar mix. I also ran a fan over night to help with drying. The car smelled like a pickle for about 4 hours, but It killed the mold smell.
    I asked about the moon roof because the drains can get clogged, causing water to back up into the car causing moldy smells as well. I'm sorry you're having issues and hope you get rid of the smell.

  8. #8
    Registered Member CX-5um's Avatar

    13' CX-5 and 16' Mazda6 both Touring w/Tech/Bose

    Join Date
    Jul 2012
    Location
    Glendale, AZ
    Posts
    3,331
    Quote Originally Posted by wifescx9 View Post
    We've taken it to a dealer to have a foaming cleanser service performed. I've also done two of my own applications just like the dealer did, via the blower fan area that leads into the HVAC system behind the center console. I've also applied foaming cleanser through the top center console vents so that it drops down onto the condenser unit, after looking at how the CX-9 is put together on a schematic. That way I'm attacking they HVAC system in both directions. No gunk comes out of the drain under the car, just foam cleanser. Once the foam settles, it just looks like clear liquid.
    What was the outcome 1 month later?

  9. #9
    Registered Member

    Mazda CX-9 GS AWD

    Join Date
    Oct 2017
    Location
    Ontario
    Posts
    12
    We have a 2010 GS with sunroof.
    My wife also complained about musty smell over the winter in ours. I pulled the carpet up on drivers side and lots of water was underneath. Underpad was soaked. I am still looking for the source. A/C drain was OK, I couldn't really find the sunroof drain holes, but will look again. Check under your carpets.

  10. #10
    Registered Member


    Join Date
    May 2019
    Posts
    63
    This may already have been done since you had the dealer do a foam clean on the AC, but you could try asking for the dealer to perfomr this TSB if the source isnít the carpets as other suggested. But if you attempted to clean the condenser many tine already this may not make a big difference.

    https://static.nhtsa.gov/odi/tsbs/20...36782-9999.pdf

  11. #11
    Registered Member

    2016.5 CX-5 GT

    Join Date
    Sep 2016
    Location
    NA
    Posts
    269
    Quote Originally Posted by wifescx9 View Post
    My wife's 2012 CX-9 has a musty mold like smell whenever her A/C kicks on. We bought it Certified Pre-Owned in 2014 with 44k miles and it didn't do it then. It has been doing it for the last 2 years and she's sick of it.

    I've gone to the following projects to solve the problem with no success.

    1) I've ran Lysol through the HAVC system.

    2) I've had the vents professionally cleaned by a detail company with vacuums and vent dusters.

    3) I've removed the glove box to inspect the white plastic basins under and to the left of the blower to inspect for excessive (or any) fluids and found nothing. I also found pure white translucency when holding a LED flashlight up to it to inspect for possible mold/mildew growth.

    4) I've jacked up the car and hooked a shop vac up to he AC evaporator drain. No fluids or gunk were removed.

    5) The cabin filter is pristine.

    Any suggestions? It is to the point she wants to sell the car because of this issue. I smell it too and it is gross.

    Thanks,
    Steve
    most likely culprit is mold and mildew growing on the evaporator coils where the airflow blows across, thus the musty smell in the cabin, only way to get rid of it it to kill the smell at the source (the coils) ; air fresheners and Lysol only mask the problem.

    there are some new products that you bacially run the HVAC system in full blast and fog the cabin with all the doors and windows closed for like 10 miunutes without anyone in the car ; so the fog will go across the coils and kill the micro-organisms

    https://www.amazon.com/Turtle-Wax-50...7SB2NYFYQ3306A
    https://www.amazon.com/Meguiars-Whol...XB6VJNYDPNS9CF

    or you can go the more direct route and find the drain tube and foam the whole evaporator core and let the foam kill the mold and mildew and let it drip out of the condensation drain, sorry I only know the location for the CX-5 but CX-9 may be similar, another way to get to the core is to remove the glove box and the fan blower housing and insert the foamer tube from there for direct access to the evap core.

    https://www.mazdas247.com/forum/show...ighlight=musty

    or another option is the remove the air filter and let the blower blow foam across the coils as in this video, you feed the air filter cavity as the blower draws the foam across the coils

    https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1

    Last edited by blackcx5; 05-28-2019 at 02:05 PM.

  12. #12
    Registered Member

    2007 Mazda CX-9 Touring

    Join Date
    Jan 2011
    Location
    new york city
    Posts
    706
    I saw this post and i would like to ask a question. Whenever i replace my cabin air filter the old one has leaves on it. Is this normal? What part of the car do the leaves get in from.

  13. #13
    Registered Member

    2019 Mazda CX-9 Signature, Machine Grey Metallic

    Join Date
    Oct 2010
    Location
    Home
    Posts
    367
    I had this issue on all the vehicles that I*ve owned. It really is caused by the condensation from the AC that doesn*t get to dry out completely. I used Klima Cleaner which works but requires quite a bit or work to use.

    The one I currently use, and has been quite effective, is the Enerzen Commercial Ozone Generator. It*s easy to use and makes the entire interior smell fresh afterwards. After treating the car, I make it a habit of turning off the AC about a mile or so away from my destination so that the AC gets a bit of chance to dry out. I have 3 vehicles and I*ve used it on all of them with the same results.

Similar Threads

  1. Musty smell through vents when A/C is OFF
    By critic81 in forum CX-9 General
    Replies: 3
    Last Post: 09-25-2014, 02:25 PM
  2. Musty smell
    By Swenny in forum Mazda5
    Replies: 13
    Last Post: 04-17-2014, 10:28 AM
  3. Replies: 16
    Last Post: 08-01-2013, 10:28 AM
  4. constant rain, mold smell?
    By FL_PR5 in forum Protege5
    Replies: 13
    Last Post: 04-03-2009, 05:57 PM
  5. Removing musty smell
    By Donas64 in forum Lounge
    Replies: 17
    Last Post: 07-02-2008, 01:56 PM

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •